Alligator Cracking Repair in Sherwood, Oregon

Quick Verdict

Alligator cracking in Sherwood is a base failure, not a surface flaw, and that changes the whole repair. The connected, reptile-skin pattern means the asphalt has lost the structural support beneath it, so sealing or sealcoating over it does nothing — the cracks come right back. The real repair is to remove the failed pavement and rebuild the base with full-depth patching. On Sherwood's Washington County clay, that often means addressing drainage and a soft sub-grade too. This guide explains why fatigue cracking happens here and what an honest, lasting fix involves.

What Alligator Cracking Actually Is

Alligator cracking — also called fatigue cracking — is what happens when asphalt is flexed past its limit too many times. Every vehicle that rolls over a weak spot bends the pavement a little. When the base underneath cannot push back, that bending fatigues the asphalt until it cracks into the tight, connected web that gives the distress its name.

Unlike a single thermal crack, alligator cracking is structural. It tells you the load is no longer carried by a sound base. Our pavement distress diagnosis guide shows how this differs from the surface cracks covered in our asphalt crack repair in Sherwood guide.

Why It Shows Up in Sherwood

Sherwood sits at the southwest edge of the metro in Washington County along the Highway 99W corridor, and several local conditions feed fatigue cracking:

• Water-holding clay. Saturated valley clay loses strength. A base over soft, wet sub-grade flexes under load and fatigues the asphalt above.
• Heavy traffic. Commercial lots and the 99W and Tonquin corridors carry loads a quiet street never sees, concentrating fatigue where vehicles turn and brake.
• Thin or aging structure. Older commercial lots paved thin years ago never had the base depth to carry today's loads.
• Drainage problems. Water lingering in low spots wicks into the base and quietly drives failure from below.

Why You Cannot Seal or Sealcoat It Away

This is the costly mistake. Sealcoat is a thin surface coating with no structural strength. Crack filler bridges a gap but restores no support. Neither puts strength back into a failed base. Spend money sealing over alligator cracking and you get a tidy lot for a few months and the same failure soon after.

If a contractor offers to "seal up" an alligatored area cheap, that is a red flag. The only honest fixes for fatigue cracking are full-depth repair of the failed sections or, when failure is widespread, reconstruction.

The Real Fix: Full-Depth Repair

A lasting repair on alligatored pavement follows these steps:

1. Saw-cut and remove the failed asphalt down to the base, cutting back to sound pavement on all sides.
2. Inspect and repair the base. On Sherwood clay this often means removing wet, contaminated rock and adding clean aggregate, sometimes with a geotextile fabric over soft sub-grade.
3. Fix drainage so water stops feeding the failure from below.
4. Pave back in lifts and compact properly so the patch carries load like the rest of the lot.

Industry Baseline Range: full-depth patching of fatigue-cracked areas typically runs in the range of $4.00 to $12.00+ per square foot depending on depth, base repair, and access. These are industry baseline ranges for planning only — actual pricing depends on lot size, access, condition, and current market conditions. Get a site-specific quote.

Current Market Reality

The cost of an alligator repair depends on how much has failed. Catch a small, isolated patch early and it is manageable. Let it spread across a Sherwood lot through a couple of wet winters and you cross from patching into full reconstruction, which costs far more. Because Oregon's paving window is May through October and Washington County crews fill up fast, early action almost always means a smaller, cheaper fix.

The Bottom Line for Sherwood Property Owners

Alligator cracking is your pavement telling you the base has failed. The cheapest path is to repair it while it is still isolated — remove the bad section, fix the base and drainage, and pave it back right. Sealing over it wastes money. Cojo provides asphalt repair services across Washington County and the 99W corridor and will tell you straight whether you need a patch or a bigger rebuild. Request an assessment and we will read your lot honestly before you spend.